Mörser Karl
Encyclopedia
"Karl-Gerät" (German
literally "Karl-device"), also known as Thor and Mörser Karl, was a World War II
German self-propelled
siege mortar
(Mörser) designed and built by Rheinmetall
. It was the largest self-propelled weapon to see service. Its heaviest munition was a 60 cm (23.6 in) diameter, 2170 kg (4,784 lb) shell, and the range for its lightest shell of 1250 kg (2,755.8 lb) was just over 10 km (6.2 mi). Each gun had to be accompanied by a crane, a heavy transport trailer, and several modified tanks to carry shells.
Seven guns were built, but only six saw combat between 1941 and 1945. It was used in attacking the Soviet fortresses of Brest-Litovsk
and Sevastopol, bombarded Polish resistance fighters in Warsaw
and participated in the Battle of the Bulge
and the attacks against the Remagen Bridgehead
. Only two exist today, the others were scrapped after the war.
. Their initial concept was for a weapon that would be transported by several tracked vehicles and assembled on site, but the lengthy preparation time drove them to change it to a self-propelled weapon in January 1937. Extensive driving trials took place in 1938 and 1939 using the first Neubaufahrzeug
tank prototype and a scale model to investigate the extremely high ground pressure and steering of such an enormous vehicle. Firing trials took place in June 1939. The full-scale driving trials were held at Unterlüss in May 1940. General Karl Becker of the Artillery was involved in the development, from whom the huge weapon gained its nickname.
In total, seven Karl-Geräte howitzers were manufactured. The first six had the nicknames "Adam", "Eva", "Thor", "Odin", "Loki", and "Ziu"; the seventh, the research and test weapon (Versuchs-Gerät), had no name. Delivery of the six production vehicles took place from November 1940 to August 1941.
In February 1941, discussions commenced concerning increasing the range of the weapon, and in May 1942, 54 cm barrels (Gerät 041) were ordered for the six vehicles. At a conference with Hitler in March 1943 it was stated that the first 54 cm Gerät 041 would be delivered by June 1943, and the third, by mid-August. Only three of the 54 cm barrels were actually completed and they could be mounted on Nr. I, IV, and V, although any vehicle could be converted to use the smaller weapon.
Twenty-two Panzer IV
Ausf. D, E and F chassis were modified with a superstructure capable of carrying four shells that replaced the turret and outfitted with a crane as Munitionsschlepper ammunition transporters/loaders. Two or three of these Munitionsschlepper were assigned to each weapon.
The 124 ton vehicle was propelled by a Daimler-Benz
MB 503 A 12-cylinder liquid-cooled gasoline engine or a MB 507 C 12 cylinder liquid-cooled diesel engine
, but this was mainly used for aiming (the mount had only 4 degrees of traverse on each side) as the engines provided a top speed of only 6.2 miles per hour (10 km/h). For longer distances the Karl-Gerät was disassembled using a special 35 tonne mobile crane into seven loads. The chassis was loaded onto a six-axle Culemeyer-Strassenroller lowboy trailer. The other parts of the gun were lighter and used four-axle trailers. If the trailer with the chassis on board had to cross a bridge that couldn't carry their combined weight the chassis had to be off-loaded and driven across under its own power. The weapon was moved long distances via rail on a variant of a Schnabel car
; the whole chassis was hung between two huge pedestal-mounted swiveling arms fixed to five-axle bogies. When it reached its destination, the weapon was detached from its supporting arms, driven to its intended firing location, then the chassis was lowered to the ground to distribute the recoil forces more evenly in preparation for firing. The Karl-Gerät proved to have no problems moving over normal soil, but under no circumstances was it allowed to make turns on soft soil lest it throw a track. The chassis had to be backed into position to fire, which expedited movement to a new position, but the firing position had to be precisely leveled and the approach route prepared ahead of time to fill in soft spots and any ditches, etc. It could only be loaded at zero elevation, so it had to be re-aimed between every shot.
The original heavy 60 cm concrete-piercing shells (schwere Betongranate) made a crater up to 15 m (49.2 ft) wide and 5 m (16.4 ft) deep. More range was desired and the light concrete-piercing shell (leichte Betongranate) 040 was introduced in 1942. Firing trials for the 54 cm shells were not completed until the end of 1944 and they were not used in combat before then. The original 60 cm heavy shell had no designation other than the name. The Gerät number was added for the newer shells.
. Initially a single battery was to be deployed against the Soviet fortress at Brest-Litovsk
, but that was changed by 14 May 1941 when the other battery was to ordered to attack the Soviet border fortifications near Lviv
. The first battery was assigned to IV Army Corps of 17th Army
of Army Group South
near Lviv
while the second battery was ordered to support the attack by the 4th Army of Army Group Center against the Brest Fortress
. The batteries were issued 60 and 36 rounds respectively.
Little is known of First Battery's operations except that IV Army Corps reported on 23 June that the battery was no longer needed and was no longer operational due to technical deficiencies. Second Battery's weapons had some assembly problems, issues with the electrical firing mechanism and non-standard ammunition, not surprising for the Karl-Geräts combat debut, but managed to fire 31 of their 36 rounds by 24 June. It was ordered home that day by Army Group Center where the battalion was ordered to reform with eight 21 cm Mörser 18 howitzers on 6 August 1941.
reported all three Karl-Geräte were at the front with a total of 72 heavy and 50 light concrete-piercing shells. LIV Army Corps reported that 19 heavy shells were fired between 2 and 6 June, 54 on 7 June and all 50 light shells between 8 and 13 June. More shells (29 heavy and 50 light) shipped to the battery before the end of the month. All 50 light shells were fired on 30 June and 25 heavy shells the following day. Many of these shells were fired at the two 305 millimetres (12 in) twin-gun armored turrets of the Maxim Gorkii coastal defense battery, although shells fired at the turrets had little effect other than to jam one of the turrets and possibly knock out electrical power to the turrets, both of which were repaired without too much trouble. They did rather more damage to the concrete structure supporting the turrets as well as the command center located some 600 meters away (called the Bastion by the Germans). On 19 July 1942 the battery was ordered to ship their weapons to Hillersleben
for refurbishment. One dud
was recovered by the Soviets and flown to Moscow
for evaluation.
On 7 July 1942 Heavy Artillery Battalion 833 was ordered to form another battery with one or two Karl-Geräte. This was done by 15 August as schwere Batterie 628 (Karl) with two weapons, although sufficient personnel to man three guns was to be furnished by Heavy Artillery Battalion 833. On 22 July the Army High Command (Oberkommando des Heeres
(OKH)) issued an order to send the battery to Army Group North
to support its planned offensive, Operation George (Unternehmen Georg), against Leningrad
. The order for Georg, dated 22 August, specified Battery 628 with three guns, presumably with two operational guns and one in reserve was to participate. Army Group North reported the battery's arrival on 1 and 2 September 1942, but the Soviets preempted Georg with heavy attacks against the German forces besieging Leningrad so the Karl-Geräte didn't get into action.
On 18 October OKH ordered the 11th Army
to transfer the battery as soon as possible to Leipzig
, but the 11th Army asked to retain it to use in a new version of Georg to begin later that month. Georg was again postponed in late October, and later canceled. A new attack, code-named Feuerzauber (Fire Magic), was planned in which the battery was to participate, but it too was canceled after the Soviet encirclement of the German forces attacking Stalingrad
. OKH finally recalled the battery on 4 December 1942 when it was clear that it had no mission.
west of Leningrad during the summer of 1943, but the battalion was ordered to return the Karl-Geräte to Leipzig on 8 August. Just like the 833rd the battalion was ordered to reform with eight 21 cm Mörser 18 howitzers on 29 August 1943 with effect by 10 September. A Unit for Karl-Geräte (Kommando für Karl-Geräte) was formed on that same date as caretakers for the weapons. This was redesignated Unit for Special-Equipment of Heavy Artillery Battalion (motorized) (Kommando für Sonder-Gerät des schwere Artillerie-Abteilung (mot.)) 628 on 2 June 1944.
On 13 August 1944 a battery was ordered to be created immediately with one 54 cm Karl-Gerät and sent to the 9th Army to help it suppress the Warsaw Uprising
. The next day the Kommando für Sonder-Geräte formed the Army Artillery Battery (Static) 638 Heeres-Artillerie Batterie (bodenständige) with 60 cm Karl-Gerät Nr. VI "Ziu" since no 54 cm weapon was available and a firing table hadn't yet been computed. It arrived at the Warsaw West train station at 0700 on 17 August 1944, although the ammunition train didn't arrive until the following morning.
On 24 August OKH noted that it had been very successful in combat and ordered another Karl-Gerät sent to Warsaw. A second battery, numbered 428, was formed 2 days later by the Kommando für Sonder-Geräte, but it didn't arrive at the Warsaw West train station until 1257 on 7 September 1944. A third Karl-Gerät 040 was shipped to Warsaw on 10 September and incorporated into Battery 428. "Ziu" needed repairs and was shipped on 22 September back to Jüterbog
. At some point a fourth Karl-Gerät was shipped to Warsaw as it was reported as operational on 25 September.
1. Karl-Geräte
Gerät Nr. I: Set up for both 040 and 041. Currently equipped with 040 with Battery 428.
Gerät Nr. II: Only set up as 040. Currently being overhauled in Jüterbog
. Motor installation will be completed in about 14 days.
Gerät Nr. III: About 14 days ago the gun tube blew apart while test firing. Only about 50% is reusable. Hitler has decided that this Gerät is to be restored to full operating condition. However, the schedule for restoring it isn't known.
Gerät Nr. IV: Set up for both 040 and 041. Currently equipped as 040 with Battery 428.
Gerät Nr. V: Set up for both 040 and 041. Equipped as a 040, it will be sent to Battery 638 in Budapest
.
Gerät Nr. VI: Only set up as 040. Came back from employment in Warsaw. Repairs will be completed in about 20 days.
Gerät Nr. VII: Versuchs-Gerät 041 Currently with the Waffenamt
for test firing and obtaining firing table data. It is not currently operational because important components (engine) are being overhauled and won't be operational before April 1945.
2. Guns
Six 54 centimetres (21.3 in) 041 guns have been ordered. Three have been completed and are stored in Jüterbog. A decision on the other three is requested because delivery will take at least 14 months.
3. 35 ton Crane
Karl-Geräte can only be employed when each battery has a 35 ton crane. Two are in service, one is in Jüterbog without its trailer, which was destroyed by fire.
4. Culemeyer-Strassenroller
Each battery needs one complete set of these heavy transport trailers. The two sets in service are set up for 040. Three 16-wheel trailers set up for 040 are available. Another 24-wheel trailer must be acquired to employ any additional Mörser Karl.
5. Munitionsschlepper
13 total, of which 6 are with Batteries 428 and 638, 2 with the Weapon Department (Waffenamt) for 040, 2 converted to 041 and 2 available.
6. Ammunition
a. Munition 040: 264 shells are immediately available, of which 150 are planned to be allotted to Battery 638. Another 96 will be completed in the next few days. 241 round are in Unterluss to change their high explosive filler. About 10 completed daily. Part of the cartridges must be reworked. Powder testing will occur on 5 October so that the rest of the ammunition can be refilled.
b. Munition 041: 50 concrete-piercing shells have been delivered to Hillersleben to be shot for firing table data in early October. 25 shells will still be delivered by the end of September, another 25 by the end of October, from then on 50 per month are planned. 50 high-explosive shells (Sprenggranaten) are to be completed for firing table data in November. In early 1945 a total of 60 HE and concrete-piercing shells are to be produced monthly.
Three days later Battery 638 was ordered to transfer to Budapest and was loaded without any Karl-Gerät. Nr. V was rerouted to Budapest to equip the battery. Battery 428 followed on 10–11 October 1944. Both batteries were ordered back to Warsaw on 19 October, although they didn't arrive until 28 October. On 6 November Battery 638 transferred one Karl-Gerät 040 to 428 and returned to Jüterbog on 10 November to rearm with a Geräte 041. Battery 428 didn't remain near Warsaw much longer and departed for Jüterbog itself on 15 November.
Battery 428 exchanged its guns for Nr. II and VI (both with Geräte 040) and departed for the West on 14 December 1944 to participate in Operation Watch on the Rhine (Unternehmen Wacht am Rhein), which would be known by Americans as the Battle of the Bulge
, but didn't reach the front until 29 December. Battery 628 followed on 20 December after equipping with Nr. IV, the first 54 cm Gerät 041 to be committed to battle.
Battery 628 was initially ordered to the Vistula Front on 7 March, but this was countermanded on 11 March and the battery was sent west to the Remagen area. The German High Command (Oberkommando der Wehrmacht
) war diary reported that 14 rounds were fired at the Remagen Bridgehead
on 20 March 1945. Battery 428 was also ordered west on 11 March, but served in the 1st Army sector.
A status report dated 22 March showed Geräte Nr. I and IV were still at Jüterbog, with Nr. I configured as a 040 and Nr. IV to be completed as a 041. Geräte Nr. II and V had left for the front on 11 and 10 March respectively. Gerät Nr. VI was returning to Jüterbog with engine damage. Gerät Nr. III had been virtually destroyed and only the gun breech
was salvageable. Gerät Nr. VII needed parts and wasn't going to be made operational anytime soon.
Battery 628 was ordered disbanded on 11 April and its personnel incorporated into Battery 428, although it's unlikely that either unit actually saw action except in local defense.
In 1945, Nr. II ("Eva") as well as Nr. V ("Loki") were captured by US forces in the period 21 March to 11 April 1945. Nr. VII, the test weapon, was captured by the US Army in Hillersleben and shipped to Aberdeen Proving Grounds but later scrapped. Nr. VI ("Ziu") was captured by the Red Army
, probably when they overran Jüterbog
on 20 April 1945. This is on display at Kubinka, although marked as Nr. I ("Adam"). Nr. IV ("Odin") was also captured by the Red Army. The fates of guns Nr. I ("Adam") and Nr. III ("Thor") are not known. It is probable both were captured by the Red Army as their last known location was in Jüterbog, less than a month earlier.
German language
German is a West Germanic language, related to and classified alongside English and Dutch. With an estimated 90 – 98 million native speakers, German is one of the world's major languages and is the most widely-spoken first language in the European Union....
literally "Karl-device"), also known as Thor and Mörser Karl, was a World War II
World War II
World War II, or the Second World War , was a global conflict lasting from 1939 to 1945, involving most of the world's nations—including all of the great powers—eventually forming two opposing military alliances: the Allies and the Axis...
German self-propelled
Self-propelled gun
A self-propelled gun is form of self-propelled artillery, and in modern use is usually used to refer to artillery pieces such as howitzers....
siege mortar
Mortar (weapon)
A mortar is an indirect fire weapon that fires explosive projectiles known as bombs at low velocities, short ranges, and high-arcing ballistic trajectories. It is typically muzzle-loading and has a barrel length less than 15 times its caliber....
(Mörser) designed and built by Rheinmetall
Rheinmetall
Rheinmetall AG is a German automotive and defence company with factories in Düsseldorf, Kassel and Unterlüß. The company has a long tradition of making guns and artillery pieces...
. It was the largest self-propelled weapon to see service. Its heaviest munition was a 60 cm (23.6 in) diameter, 2170 kg (4,784 lb) shell, and the range for its lightest shell of 1250 kg (2,755.8 lb) was just over 10 km (6.2 mi). Each gun had to be accompanied by a crane, a heavy transport trailer, and several modified tanks to carry shells.
Seven guns were built, but only six saw combat between 1941 and 1945. It was used in attacking the Soviet fortresses of Brest-Litovsk
Brest Fortress
Brest Fortress , formerly known as Brest-Litovsk Fortress , is a 19th century Russian fortress in Brest, Belarus. It is one of the most important Soviet World War II war monuments commemorating the Soviet resistance against the German invasion on June 22, 1941...
and Sevastopol, bombarded Polish resistance fighters in Warsaw
Warsaw Uprising
The Warsaw Uprising was a major World War II operation by the Polish resistance Home Army , to liberate Warsaw from Nazi Germany. The rebellion was timed to coincide with the Soviet Union's Red Army approaching the eastern suburbs of the city and the retreat of German forces...
and participated in the Battle of the Bulge
Battle of the Bulge
The Battle of the Bulge was a major German offensive , launched toward the end of World War II through the densely forested Ardennes mountain region of Wallonia in Belgium, hence its French name , and France and...
and the attacks against the Remagen Bridgehead
Ludendorff Bridge
The Ludendorff Bridge was a railway bridge across the River Rhine in Germany, connecting the villages of Remagen and Erpel between two ridge lines of hills flanking the river...
. Only two exist today, the others were scrapped after the war.
Development
In March 1936 Rheinmetall made a proposal for a super-heavy howitzer to attack the Maginot LineMaginot Line
The Maginot Line , named after the French Minister of War André Maginot, was a line of concrete fortifications, tank obstacles, artillery casemates, machine gun posts, and other defences, which France constructed along its borders with Germany and Italy, in light of its experience in World War I,...
. Their initial concept was for a weapon that would be transported by several tracked vehicles and assembled on site, but the lengthy preparation time drove them to change it to a self-propelled weapon in January 1937. Extensive driving trials took place in 1938 and 1939 using the first Neubaufahrzeug
Neubaufahrzeug
The German Neubaufahrzeug series of tank prototypes were a first attempt to create a heavy tank for the Wehrmacht after Adolf Hitler had come to power. Multi-turreted, heavy and slow, they did not fit in with the Blitzkrieg tactics and therefore only five were made...
tank prototype and a scale model to investigate the extremely high ground pressure and steering of such an enormous vehicle. Firing trials took place in June 1939. The full-scale driving trials were held at Unterlüss in May 1940. General Karl Becker of the Artillery was involved in the development, from whom the huge weapon gained its nickname.
In total, seven Karl-Geräte howitzers were manufactured. The first six had the nicknames "Adam", "Eva", "Thor", "Odin", "Loki", and "Ziu"; the seventh, the research and test weapon (Versuchs-Gerät), had no name. Delivery of the six production vehicles took place from November 1940 to August 1941.
In February 1941, discussions commenced concerning increasing the range of the weapon, and in May 1942, 54 cm barrels (Gerät 041) were ordered for the six vehicles. At a conference with Hitler in March 1943 it was stated that the first 54 cm Gerät 041 would be delivered by June 1943, and the third, by mid-August. Only three of the 54 cm barrels were actually completed and they could be mounted on Nr. I, IV, and V, although any vehicle could be converted to use the smaller weapon.
Twenty-two Panzer IV
Panzer IV
The Panzerkampfwagen IV , commonly known as the Panzer IV, was a medium tank developed in Nazi Germany in the late 1930s and used extensively during the Second World War. Its ordnance inventory designation was Sd.Kfz...
Ausf. D, E and F chassis were modified with a superstructure capable of carrying four shells that replaced the turret and outfitted with a crane as Munitionsschlepper ammunition transporters/loaders. Two or three of these Munitionsschlepper were assigned to each weapon.
Variants
- Gerät 040: original model, armed with a short 60 centimetres (23.6 in) caliber barrel;
- Gerät 041: later model, armed with a long (L/11.55) 54 centimetres (21.3 in) caliber barrel.
Description
Daimler-Benz
Daimler-Benz AG was a German manufacturer of automobiles, motor vehicles, and internal combustion engines; founded in 1926. An Agreement of Mutual Interest - which was valid until year 2000 - was signed on 1 May 1924 between Karl Benz's Benz & Cie., and Daimler Motoren Gesellschaft, which had...
MB 503 A 12-cylinder liquid-cooled gasoline engine or a MB 507 C 12 cylinder liquid-cooled diesel engine
Diesel engine
A diesel engine is an internal combustion engine that uses the heat of compression to initiate ignition to burn the fuel, which is injected into the combustion chamber...
, but this was mainly used for aiming (the mount had only 4 degrees of traverse on each side) as the engines provided a top speed of only 6.2 miles per hour (10 km/h). For longer distances the Karl-Gerät was disassembled using a special 35 tonne mobile crane into seven loads. The chassis was loaded onto a six-axle Culemeyer-Strassenroller lowboy trailer. The other parts of the gun were lighter and used four-axle trailers. If the trailer with the chassis on board had to cross a bridge that couldn't carry their combined weight the chassis had to be off-loaded and driven across under its own power. The weapon was moved long distances via rail on a variant of a Schnabel car
Schnabel car
A Schnabel car is a specialized type of railroad freight car. It is designed to carry heavy and oversized loads in such a way that the load itself makes up part of the car...
; the whole chassis was hung between two huge pedestal-mounted swiveling arms fixed to five-axle bogies. When it reached its destination, the weapon was detached from its supporting arms, driven to its intended firing location, then the chassis was lowered to the ground to distribute the recoil forces more evenly in preparation for firing. The Karl-Gerät proved to have no problems moving over normal soil, but under no circumstances was it allowed to make turns on soft soil lest it throw a track. The chassis had to be backed into position to fire, which expedited movement to a new position, but the firing position had to be precisely leveled and the approach route prepared ahead of time to fill in soft spots and any ditches, etc. It could only be loaded at zero elevation, so it had to be re-aimed between every shot.
Automotive features
The various Karl-Geräte used two different types of transmissions, engines and suspension system in a bewildering set of combinations. The table below outlines how each vehicle was outfitted. After May 1944 the gasoline engines were replaced by diesels. Little information is available for Nr. VII, the experimental model, and the data below must be regarded as unconfirmed.| No. | I | II | III | IV | V | VI | VII |
| Ausf. | 1 | 2 | 3 | 3 | 4 | 5 | 6 |
| Engine | MB 503 A | MB 503 A | MB 507 C | MB 507 C | MB 507 C | MB 503 A | MB 503 A |
| Transmission | 4 speed Ardelt | 3 speed Voith Turbo | 4 speed Ardelt | 4 speed Ardelt | 3 speed Voith Turbo | 3 speed Voith Turbo | 4 speed Ardelt |
| Speed | 10 km/h | 10 km/h | 6 km/h | 6 km/h | 6 km/h | 6 km/h | 6 km/h |
| Range | 42 km | 42 km | 60 km | 60 km | 60 km | 42 km | 42 km |
| Roadwheels (rim) | 8 rubber | 8 rubber | 11 steel | 11 steel | 11 steel | 11 steel | 11 steel |
| Return rollers | 8 rubber | 8 rubber | 6 rubber | 6 rubber | 6 rubber | 6 rubber | 6 rubber |
| Torsion bars | 2600 mm | 2600 mm | 2115 mm | 2115 mm | 2115 mm | 2115 mm | 2115 mm |
| Track pitch | 170 mm | 170 mm | 250 mm | 240 mm | 240 mm | 240 mm | 240 mm |
| Link per side | 133 | 133 | 94 | 94 | 94 | 94 | 94 |
| Sprocket teeth | 17 | 17 | 12 | 12 | 12 | 12 | 12 |
Ammunition
| Shell | Caliber | Weight | Weight of explosive fill | Muzzle velocity | Max range | Penetration |
| heavy concrete-piercing shell (schwere Betongranate) | 60 cm (23.6 in) | 2170 kg (4,784 lb) | 289 kg (637.1 lb) | 220 m/s (721.8 ft/s) | 4320 m (4,724.4 yd) | 2.5 metres (8.2 ft) + of concrete |
| light concrete-piercing shell (leichte Betongranate) 040 | 60 cm (23.6 in) | 1700 kg (3,747.9 lb) | 220 kg (485 lb) | 283 m/s (928.5 ft/s) | 6440 m (7,042.9 yd) | 2.5 metres (8.2 ft) + of concrete |
| light concrete-piercing shell (leichte Betongranate) 041 | 54 cm (21.3 in) | 1250 kg (2,755.8 lb) | no data | 378 m/s (1,240.2 ft/s) | 10060 m (11,001.7 yd) | 3–3.5 m (9.8–11.5 ft) of concrete |
| high-explosive shell (Sprenggranate) 041 | 54 cm (21.3 in) | no data | no data | no data | no data | no data |
1941
On 3 January 1941 Heavy Battery (schwere Batterie) 833 was created at the Bergen training ground and ordered to be combat ready by 15 February 1941. On 2 April 1941 it was expanded into Heavy Artillery Battalion (schwere Artillerie Bataillon) 833. The original Batterie 833 was redesignated as the first battery of the new battalion and a new second battery was formed, each battery having two howitzers, with orders to be combat ready by 1 May 1941 in preparation for Operation BarbarossaOperation Barbarossa
Operation Barbarossa was the code name for Germany's invasion of the Soviet Union during World War II that began on 22 June 1941. Over 4.5 million troops of the Axis powers invaded the USSR along a front., the largest invasion in the history of warfare...
. Initially a single battery was to be deployed against the Soviet fortress at Brest-Litovsk
Brest Fortress
Brest Fortress , formerly known as Brest-Litovsk Fortress , is a 19th century Russian fortress in Brest, Belarus. It is one of the most important Soviet World War II war monuments commemorating the Soviet resistance against the German invasion on June 22, 1941...
, but that was changed by 14 May 1941 when the other battery was to ordered to attack the Soviet border fortifications near Lviv
Lviv
Lviv is a city in western Ukraine. The city is regarded as one of the main cultural centres of today's Ukraine and historically has also been a major Polish and Jewish cultural center, as Poles and Jews were the two main ethnicities of the city until the outbreak of World War II and the following...
. The first battery was assigned to IV Army Corps of 17th Army
17th Army (Germany)
The German Seventeenth Army was a World War II field army.-Commanding officers:* General der Infanterie Carl-Heinrich von Stülpnagel * Generaloberst Hermann Hoth...
of Army Group South
Army Group South
Army Group South was the name of a number of German Army Groups during World War II.- Poland campaign :Germany used two army groups to invade Poland in 1939: Army Group North and Army Group South...
near Lviv
Lviv
Lviv is a city in western Ukraine. The city is regarded as one of the main cultural centres of today's Ukraine and historically has also been a major Polish and Jewish cultural center, as Poles and Jews were the two main ethnicities of the city until the outbreak of World War II and the following...
while the second battery was ordered to support the attack by the 4th Army of Army Group Center against the Brest Fortress
Brest Fortress
Brest Fortress , formerly known as Brest-Litovsk Fortress , is a 19th century Russian fortress in Brest, Belarus. It is one of the most important Soviet World War II war monuments commemorating the Soviet resistance against the German invasion on June 22, 1941...
. The batteries were issued 60 and 36 rounds respectively.
Little is known of First Battery's operations except that IV Army Corps reported on 23 June that the battery was no longer needed and was no longer operational due to technical deficiencies. Second Battery's weapons had some assembly problems, issues with the electrical firing mechanism and non-standard ammunition, not surprising for the Karl-Geräts combat debut, but managed to fire 31 of their 36 rounds by 24 June. It was ordered home that day by Army Group Center where the battalion was ordered to reform with eight 21 cm Mörser 18 howitzers on 6 August 1941.
1942
In preparation for the attack on Sevastopol scheduled for the early summer Heavy Artillery Battalion 833 was ordered to form a Karl-Batterie with three weapons on 18 February 1942, two of which were "Thor" and "Odin". Camouflaged firing positions 15 metres (49.2 ft) long, 10 metres (32.8 ft) wide and 3 metres (9.8 ft) deep had to be dug for each howitzer to minimize Soviet counter-fire before they could move into position. On 20 May 1942 11th Army11th Army (Germany)
The 11th Army was a World War I and a World War II field army.-World War I:The 11th Army was formed in early 1915. It briefly fought on the Western Front during the Battle of Ypres, holding the line against the allied attack...
reported all three Karl-Geräte were at the front with a total of 72 heavy and 50 light concrete-piercing shells. LIV Army Corps reported that 19 heavy shells were fired between 2 and 6 June, 54 on 7 June and all 50 light shells between 8 and 13 June. More shells (29 heavy and 50 light) shipped to the battery before the end of the month. All 50 light shells were fired on 30 June and 25 heavy shells the following day. Many of these shells were fired at the two 305 millimetres (12 in) twin-gun armored turrets of the Maxim Gorkii coastal defense battery, although shells fired at the turrets had little effect other than to jam one of the turrets and possibly knock out electrical power to the turrets, both of which were repaired without too much trouble. They did rather more damage to the concrete structure supporting the turrets as well as the command center located some 600 meters away (called the Bastion by the Germans). On 19 July 1942 the battery was ordered to ship their weapons to Hillersleben
Hillersleben
Hillersleben is a village and a former municipality in the Börde district in Saxony-Anhalt, Germany. Since 1 January 2010, it is part of the municipality Westheide....
for refurbishment. One dud
Dud
A dud is an ammunition round or explosive that fails to fire or detonate, respectively, on time or on command.Duds are still dangerous and have to be deactivated and disposed of carefully. Poorly designed devices A dud is an ammunition round or explosive that fails to fire or detonate,...
was recovered by the Soviets and flown to Moscow
Moscow
Moscow is the capital, the most populous city, and the most populous federal subject of Russia. The city is a major political, economic, cultural, scientific, religious, financial, educational, and transportation centre of Russia and the continent...
for evaluation.
On 7 July 1942 Heavy Artillery Battalion 833 was ordered to form another battery with one or two Karl-Geräte. This was done by 15 August as schwere Batterie 628 (Karl) with two weapons, although sufficient personnel to man three guns was to be furnished by Heavy Artillery Battalion 833. On 22 July the Army High Command (Oberkommando des Heeres
Oberkommando des Heeres
The Oberkommando des Heeres was Nazi Germany's High Command of the Army from 1936 to 1945. The Oberkommando der Wehrmacht commanded OKH only in theory...
(OKH)) issued an order to send the battery to Army Group North
Army Group North
Army Group North was a German strategic echelon formation commanding a grouping of Field Armies subordinated to the OKH during World War II. The army group coordinated the operations of attached separate army corps, reserve formations, rear services and logistics.- Formation :The Army Group North...
to support its planned offensive, Operation George (Unternehmen Georg), against Leningrad
Siege of Leningrad
The Siege of Leningrad, also known as the Leningrad Blockade was a prolonged military operation resulting from the failure of the German Army Group North to capture Leningrad, now known as Saint Petersburg, in the Eastern Front theatre of World War II. It started on 8 September 1941, when the last...
. The order for Georg, dated 22 August, specified Battery 628 with three guns, presumably with two operational guns and one in reserve was to participate. Army Group North reported the battery's arrival on 1 and 2 September 1942, but the Soviets preempted Georg with heavy attacks against the German forces besieging Leningrad so the Karl-Geräte didn't get into action.
On 18 October OKH ordered the 11th Army
11th Army (Germany)
The 11th Army was a World War I and a World War II field army.-World War I:The 11th Army was formed in early 1915. It briefly fought on the Western Front during the Battle of Ypres, holding the line against the allied attack...
to transfer the battery as soon as possible to Leipzig
Leipzig
Leipzig Leipzig has always been a trade city, situated during the time of the Holy Roman Empire at the intersection of the Via Regia and Via Imperii, two important trade routes. At one time, Leipzig was one of the major European centres of learning and culture in fields such as music and publishing...
, but the 11th Army asked to retain it to use in a new version of Georg to begin later that month. Georg was again postponed in late October, and later canceled. A new attack, code-named Feuerzauber (Fire Magic), was planned in which the battery was to participate, but it too was canceled after the Soviet encirclement of the German forces attacking Stalingrad
Battle of Stalingrad
The Battle of Stalingrad was a major battle of World War II in which Nazi Germany and its allies fought the Soviet Union for control of the city of Stalingrad in southwestern Russia. The battle took place between 23 August 1942 and 2 February 1943...
. OKH finally recalled the battery on 4 December 1942 when it was clear that it had no mission.
1943
OKH issued orders to create a Heavy Artillery Battalion (Karl) on 4 May 1943 using the vehicles and equipment of Heavy Artillery Battery 628. This became the first battery of the new battalion while the other battery was raised from scratch on 15 May as was the battalion headquarters. Each battery had two Karl-Geräte plus a fifth in reserve. 18th Army of Army Group North had plans to use one Karl-Gerät against the Oranienbaum BridgeheadOranienbaum Bridgehead
The Oranienbaum Bridgehead was an isolated portion of the Leningrad Oblast in Russia, which was retained under Soviet control during the siege of Leningrad in World War II...
west of Leningrad during the summer of 1943, but the battalion was ordered to return the Karl-Geräte to Leipzig on 8 August. Just like the 833rd the battalion was ordered to reform with eight 21 cm Mörser 18 howitzers on 29 August 1943 with effect by 10 September. A Unit for Karl-Geräte (Kommando für Karl-Geräte) was formed on that same date as caretakers for the weapons. This was redesignated Unit for Special-Equipment of Heavy Artillery Battalion (motorized) (Kommando für Sonder-Gerät des schwere Artillerie-Abteilung (mot.)) 628 on 2 June 1944.
1944
Warsaw Uprising
The Warsaw Uprising was a major World War II operation by the Polish resistance Home Army , to liberate Warsaw from Nazi Germany. The rebellion was timed to coincide with the Soviet Union's Red Army approaching the eastern suburbs of the city and the retreat of German forces...
. The next day the Kommando für Sonder-Geräte formed the Army Artillery Battery (Static) 638 Heeres-Artillerie Batterie (bodenständige) with 60 cm Karl-Gerät Nr. VI "Ziu" since no 54 cm weapon was available and a firing table hadn't yet been computed. It arrived at the Warsaw West train station at 0700 on 17 August 1944, although the ammunition train didn't arrive until the following morning.
On 24 August OKH noted that it had been very successful in combat and ordered another Karl-Gerät sent to Warsaw. A second battery, numbered 428, was formed 2 days later by the Kommando für Sonder-Geräte, but it didn't arrive at the Warsaw West train station until 1257 on 7 September 1944. A third Karl-Gerät 040 was shipped to Warsaw on 10 September and incorporated into Battery 428. "Ziu" needed repairs and was shipped on 22 September back to Jüterbog
Jüterbog
Jüterbog is a historic town in north-eastern Germany, located in the Teltow-Fläming district of Brandenburg. It is located on the Nuthe river at the northern slope of the Fläming hill range, about southwest of Berlin.-History:...
. At some point a fourth Karl-Gerät was shipped to Warsaw as it was reported as operational on 25 September.
Report
A meeting was held on 29 September by the OKH General der Artillerie to discuss the overall status of the Karl-Gerät, its supporting equipment and ammunition:1. Karl-Geräte
Gerät Nr. I: Set up for both 040 and 041. Currently equipped with 040 with Battery 428.
Gerät Nr. II: Only set up as 040. Currently being overhauled in Jüterbog
Jüterbog
Jüterbog is a historic town in north-eastern Germany, located in the Teltow-Fläming district of Brandenburg. It is located on the Nuthe river at the northern slope of the Fläming hill range, about southwest of Berlin.-History:...
. Motor installation will be completed in about 14 days.
Gerät Nr. III: About 14 days ago the gun tube blew apart while test firing. Only about 50% is reusable. Hitler has decided that this Gerät is to be restored to full operating condition. However, the schedule for restoring it isn't known.
Gerät Nr. IV: Set up for both 040 and 041. Currently equipped as 040 with Battery 428.
Gerät Nr. V: Set up for both 040 and 041. Equipped as a 040, it will be sent to Battery 638 in Budapest
Budapest
Budapest is the capital of Hungary. As the largest city of Hungary, it is the country's principal political, cultural, commercial, industrial, and transportation centre. In 2011, Budapest had 1,733,685 inhabitants, down from its 1989 peak of 2,113,645 due to suburbanization. The Budapest Commuter...
.
Gerät Nr. VI: Only set up as 040. Came back from employment in Warsaw. Repairs will be completed in about 20 days.
Gerät Nr. VII: Versuchs-Gerät 041 Currently with the Waffenamt
Waffenamt
Waffenamt was the German Army Weapons Agency. It was the centre for research and development of Germany and also during the Third Reich for weapons, ammunition and army equipment to the German Reichswehr and later Wehrmacht...
for test firing and obtaining firing table data. It is not currently operational because important components (engine) are being overhauled and won't be operational before April 1945.
2. Guns
Six 54 centimetres (21.3 in) 041 guns have been ordered. Three have been completed and are stored in Jüterbog. A decision on the other three is requested because delivery will take at least 14 months.
3. 35 ton Crane
Karl-Geräte can only be employed when each battery has a 35 ton crane. Two are in service, one is in Jüterbog without its trailer, which was destroyed by fire.
Each battery needs one complete set of these heavy transport trailers. The two sets in service are set up for 040. Three 16-wheel trailers set up for 040 are available. Another 24-wheel trailer must be acquired to employ any additional Mörser Karl.
5. Munitionsschlepper
13 total, of which 6 are with Batteries 428 and 638, 2 with the Weapon Department (Waffenamt) for 040, 2 converted to 041 and 2 available.
6. Ammunition
a. Munition 040: 264 shells are immediately available, of which 150 are planned to be allotted to Battery 638. Another 96 will be completed in the next few days. 241 round are in Unterluss to change their high explosive filler. About 10 completed daily. Part of the cartridges must be reworked. Powder testing will occur on 5 October so that the rest of the ammunition can be refilled.
b. Munition 041: 50 concrete-piercing shells have been delivered to Hillersleben to be shot for firing table data in early October. 25 shells will still be delivered by the end of September, another 25 by the end of October, from then on 50 per month are planned. 50 high-explosive shells (Sprenggranaten) are to be completed for firing table data in November. In early 1945 a total of 60 HE and concrete-piercing shells are to be produced monthly.
Three days later Battery 638 was ordered to transfer to Budapest and was loaded without any Karl-Gerät. Nr. V was rerouted to Budapest to equip the battery. Battery 428 followed on 10–11 October 1944. Both batteries were ordered back to Warsaw on 19 October, although they didn't arrive until 28 October. On 6 November Battery 638 transferred one Karl-Gerät 040 to 428 and returned to Jüterbog on 10 November to rearm with a Geräte 041. Battery 428 didn't remain near Warsaw much longer and departed for Jüterbog itself on 15 November.
Battery 428 exchanged its guns for Nr. II and VI (both with Geräte 040) and departed for the West on 14 December 1944 to participate in Operation Watch on the Rhine (Unternehmen Wacht am Rhein), which would be known by Americans as the Battle of the Bulge
Battle of the Bulge
The Battle of the Bulge was a major German offensive , launched toward the end of World War II through the densely forested Ardennes mountain region of Wallonia in Belgium, hence its French name , and France and...
, but didn't reach the front until 29 December. Battery 628 followed on 20 December after equipping with Nr. IV, the first 54 cm Gerät 041 to be committed to battle.
1945
Little is known of their activities during the battle, but Gerät Nr. II was damaged enroute by a bomb and was back in Jüterbog on 6 January 1945. It was repaired using parts from Karl Nr. I by 3 February. Gerät Nr. IV was damaged by a number of penetrating hits and arrived in Jüterbog on 31 January. Gerät Nr. VI was still at the front on 19 January. In the meantime Nr. V was modified to use the 54 cm howitzer and had its engine rebuilt.Battery 628 was initially ordered to the Vistula Front on 7 March, but this was countermanded on 11 March and the battery was sent west to the Remagen area. The German High Command (Oberkommando der Wehrmacht
Oberkommando der Wehrmacht
The Oberkommando der Wehrmacht was part of the command structure of the armed forces of Nazi Germany during World War II.- Genesis :...
) war diary reported that 14 rounds were fired at the Remagen Bridgehead
Ludendorff Bridge
The Ludendorff Bridge was a railway bridge across the River Rhine in Germany, connecting the villages of Remagen and Erpel between two ridge lines of hills flanking the river...
on 20 March 1945. Battery 428 was also ordered west on 11 March, but served in the 1st Army sector.
A status report dated 22 March showed Geräte Nr. I and IV were still at Jüterbog, with Nr. I configured as a 040 and Nr. IV to be completed as a 041. Geräte Nr. II and V had left for the front on 11 and 10 March respectively. Gerät Nr. VI was returning to Jüterbog with engine damage. Gerät Nr. III had been virtually destroyed and only the gun breech
Breech-loading weapon
A breech-loading weapon is a firearm in which the cartridge or shell is inserted or loaded into a chamber integral to the rear portion of a barrel....
was salvageable. Gerät Nr. VII needed parts and wasn't going to be made operational anytime soon.
Battery 628 was ordered disbanded on 11 April and its personnel incorporated into Battery 428, although it's unlikely that either unit actually saw action except in local defense.
Fate
Red Army
The Workers' and Peasants' Red Army started out as the Soviet Union's revolutionary communist combat groups during the Russian Civil War of 1918-1922. It grew into the national army of the Soviet Union. By the 1930s the Red Army was among the largest armies in history.The "Red Army" name refers to...
, probably when they overran Jüterbog
Jüterbog
Jüterbog is a historic town in north-eastern Germany, located in the Teltow-Fläming district of Brandenburg. It is located on the Nuthe river at the northern slope of the Fläming hill range, about southwest of Berlin.-History:...
on 20 April 1945. This is on display at Kubinka, although marked as Nr. I ("Adam"). Nr. IV ("Odin") was also captured by the Red Army. The fates of guns Nr. I ("Adam") and Nr. III ("Thor") are not known. It is probable both were captured by the Red Army as their last known location was in Jüterbog, less than a month earlier.
See also
- Siege artillery
- List of the largest cannon by caliber